Utilize este identificador para referenciar este registo: http://hdl.handle.net/10400.14/7967
Título: Solvent extraction of sodium chloride from codfish (Gadus morhua) salting processing wastewater
Autor: Ferraro, Vincenza
Cruz, Isabel B.
Jorge, Ruben Ferreira
Pintado, Manuela E.
Castro, Paula M. L.
Palavras-chave: Salting wastewater
Free amino acids
Salt extraction
Solvent extraction
Data: 2011
Editora: Elsevier
Citação: FERRARO, Vincenza... [et al.] - Solvent extraction of sodium chloride from codfish (Gadus morhua) salting processing wastewater. Desalination. ISSN 0011-9164. Vol. 281, n.º 17 (2011), p. 42-48
Resumo: Codfish is worldwide mostly consumed salt-cured due to the highly appreciated sensory characteristics promoted by salt. During the salting process huge amounts of salted wastewater are generated – approximately 22% w/w of the codfish – carrying ca. 250 g/L of sodium chloride and ca. 10 g/L of organic compounds, namely proteins and free amino acids. In this study, the salt load of wastewater generated during the salting process of codfish (Gadus morhua) was successfully reduced by ethanol extraction. The effects of time, sample:ethanol ratio, pH and temperature on salt extraction by ethanol addition were assessed by a onevariable-at-a-time approach and then by performing a 32 fractional factorial design. The effects of pH were also assessed in absence of ethanol. The maximum amount of salt precipitated in the wastewater was ca. 33%, at a wastewater-ethanol ratio 1:1 (v/v), at a temperature of 0 °C and after 30 min. Proteins and free amino acids present in the wastewater significantly limited salt precipitation; in a blank solution (salt in water at ca. 250 g/L) a higher amount of salt, ca. 37%, was precipitated in the same conditions. Ethanol and temperature showed a linear effect on salt precipitation for both wastewater and blank solution however ethanol was the driving factor. Changes in pH did not result in salt precipitation either in absence or presence of ethanol. During salt extraction, no precipitation of free amino acids occurred in the wastewater while ca. 1.4% of protein fell into the precipitated phase along with the salt.
Peer review: yes
URI: http://hdl.handle.net/10400.14/7967
Versão do Editor: http://www.sciencedirect.com/science/article/pii/S0011916411006527
Aparece nas colecções:CBQF - Artigos em revistas internacionais com Arbitragem / Papers in international journals with Peer-review

Ficheiros deste registo:
Ficheiro Descrição TamanhoFormato 
1-s2.0-S0011916411006527-main.1.pdf621,76 kBAdobe PDFVer/Abrir

FacebookTwitterDeliciousLinkedInDiggGoogle BookmarksMySpace
Formato BibTex MendeleyEndnote Degois 

Todos os registos no repositório estão protegidos por leis de copyright, com todos os direitos reservados.